LPV Correct control of air direction, volume, and velocity

©

The LPV system is a classic negative pressure system used for ventilation of pig production facilities. The system is intended for temperate regions of the world, and it can be adapted to most livestock buildings.

The LPV system is a classic negative pressure system used for ventilation of pig production facilities. The system is intended for temperate regions of the world, and it can be adapted to most livestock buildings.

In an LPV system, the wall, ceiling, or roof inlets supply fresh air. During cold periods, fresh air is mixed with the housing air before it reaches the area occupied by the pigs.

During warm periods, the air enters the same way but is sucked into the livestock house at a higher speed. It results in air circulation around the pigs, and they are cooled without perceiving the increased air circulation as a draught.

The system automatically adapts ventilation based on the outside temperature, production type, and age of the pigs.

The exhaust units are adjusted according to the Dynamic MultiStep principle, which substantially reduces the power consumption.

Air inlet
For all purposes

SKOV offers a wide variety of air inlets, meaning that no matter the location of your livestock house and we have an air inlet suited to your needs.

Depending on the age and requirements of the animals, the right amount of air must enter the house in an optimum direction and at the right height and velocity.

At low outdoor temperatures, the negative pressure causes cold air to be sucked into the livestock house. The air must not reach the animals in the livestock house without it being mixed with the housing air first.

It is essential to remove the excess heat from the animals at high outside temperatures and create air movement around them to provide a cooling effect.

Reduce energy consumption
to 6 kWh per pen place with Dynamic MultiStep®

Heating and ventilation are some of the worst offenders when it comes to high-energy bills for pig production. However, you can reduce the power consumption for ventilation significantly.

Stepless regulation extends minimum ventilation
It is well known that considerably more power is consumed at high fan capacity than at low capacity. That is why SKOV developed Dynamic MultiStep®, resulting in the fans being connected in groups at approx. 50% of their output. Once all the fans are connected, they are regulated up to 100% of their output in parallel, should additional ventilation be required. Or in other words, because more fans are employed, they can run at a lower output. This reduces power consumption significantly while still maintaining a good climate in the house.

Significant reduction of energy consumption
Studies conducted at a Danish pork production site showed that they could drive down energy consumption to only 6-10 kWh per pen place annually. Energy consumption is reduced, and the animals have the same good climate conditions – the only notable change was that the noise level was also reduced, much to the pleasure of both employees and animals. ​

DA 600/820/920 chimney
Wide range of chimney solutions for all purposes

DA 600/820/920 is a series of robust and efficient exhaust units. The series of aerodynamic chimneys is developed for maximum air output at low energy consumption levels.

The chimneys are particularly robust under all weather conditions and have a very long service life.

The chimneys are custom-fit to the building and can be used on virtually any type of livestock house. They can be adjusted to fit the roof pitch of individual buildings, color, and placement.

LPC is a series of energy-efficient fans that are particularly suitable for ventilation of livestock houses and optimized to work with SKOV's ventilation systems and chimneys. The LPC fan has a high level of pressure stability, and it is less sensitive to wind.

Benefits:

Aerodynamic and optimized to the LPC fan

Maximum air output at low energy consumption

Robust under all weather conditions

Profiled roofing sheets – no need for sealing

Side or ridge-mounted – easily adapted to the roof
Accessories:

Drip trays, light bowls, and environmental modules


LLC "AgroClimate Ukraine":

 

2 660 Kyiv, Ukraine;

19, Yevhen Sverstyuk Street, office 914

+38 067 386 26 91, +38 829 52 62, +38 067 537 36 67

 

volodymyr.brovchenko15@gmail.com

 

agroclimate.com.ua

biopulsilo.com/ua/